diamond forged .020 pistons

razorryan10

Member
Feb 18, 2019
30
0
6
canada
in the middle of collecting parts for a lly motor build, question i have is how much daily driving can be done on a set of forged pistons piston/wall clearance is .006-.0065
power goal of a 1000hp and daily around 800hp

got a good deal on forged pistons only reason for going that route
 

Chevy1925

don't know sh!t about IFS
Staff member
Oct 21, 2009
21,126
4,867
113
Phoenix Az
I’d tighten up piston to wall clearance a bit but there are guys that have put thousands of miles on forged pistons before. Rings just see more wear. I’ve not seen anyone do a ring gap comparison after high miles put on them. Might have been one or two in the past??? Can’t remember.

Most guys are on cast pistons in that range where it’s a non issue and much tighter piston to wall clearance.
 

razorryan10

Member
Feb 18, 2019
30
0
6
canada
alright sounds like a non issue for me to worry about, ill just tighten wall clearance up to .003-.004
over building it for my needs, planning for future upgrades
 

Chevy1925

don't know sh!t about IFS
Staff member
Oct 21, 2009
21,126
4,867
113
Phoenix Az
.004 would be as tight as I go. There is no “range” if the machine shop is good. If you want .0042, they can hit that to the largest piston. The only range is the little bit of piston dia but you should see next to none on new pistons
 

Bdsankey

Vendor
Vendor/Sponsor
Feb 1, 2018
3,906
1,074
113
Neenah, Wisconsin
If your goal is around 800whp with a couple trips to 4 digits IMO a cast piston would be better suited. As for PTW, my CP forged were recommended at 0.006-0.008 and provided a handy formula to punch in for diameter and usage. My pistons went in at 0.0065" based on their formula and conversations I had with other engine builders.


The problem with going outside the manufacturer's spec is that the forged pistons grow substantially with heat. I don't know what material Diamond uses but it may be worth looking at what the thermal expansion rate is on that material.
 

56taskforce

Well-known member
Mar 30, 2014
1,074
51
48
Stay with cast for street driven. Unlike gas power the biggest drawback isn't cold piston slap. In deisel applications the big drawback to forged pistons is ring land wear.
 

Fingers

Village Idiot
Vendor/Sponsor
Apr 1, 2008
1,713
84
48
White Oak, PA
The problem with Forged on the street, IMO, is the blowby. To have enough clearance when you lean on them, you have to accept the looser clearances. Ring wear is another issue, but there are steel land forged available to deal with that.

Just know what you are getting into.
 

razorryan10

Member
Feb 18, 2019
30
0
6
canada
blowby im ok with it has alittle bit now as it is lol, if i can get 20k-25k kms out of them that will take 3 years or more by then the truck will be rutted out again anyway from being in canada