TSBs [Archive] - Duramax Diesels Forum
PDA

View Full Version : TSBs

  1. #00-02-35-003N: Clunking Noise Under Hood and Can Be Felt in Steering Wheel and/or St
  2. #00-03-10-002D: Info - Chemical Staining, Pitting, Corrosion and/or Spotted Appearanc
  3. #00-08-48-005C: Distortion in Outer Surface of Vehicle Glass - (Feb 1, 2008)
  4. #01-04-18-001F: Driveline Characteristics for All-Wheel Drive (AWD) and Four-Wheel Dr
  5. #01-06-01-011D: Information on Engine Oil Consumption Guidelines - (Apr 3, 2007)
  6. #02-06-01-022G: Information on Engine Ticking Noise - (Jun 19, 2007)
  7. #02-08-46-007D: Information on OnStar System - Possible Loss of GPS Signal, Hands-Fre
  8. #03-03-09-002B: Rear Leaf Spring Slap or Clunk Noise (Replace Spring Inserts) - (Jul
  9. #03-06-04-017D: Information on Diesel Fuel Additives - (Feb 20, 2007)
  10. #03-06-04-036A: Information on Servicing Fuel Injectors to Avoid Contamination - (Oct
  11. #04-06-04-001C: LB7/LBZ/LLY/LMM - Intermittent Driveability Conditions-No Crank, Cran
  12. #04-06-04-007H: Service Engine Soon (SES) Light On, DTCs P0087, P0092, P1093, Low Pow
  13. #04-08-48-003: Windrush Around Windshield (Install New Windshield Reveal Moldings) -
  14. #04-08-50-006B: Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer I
  15. #05-00-89-072A: Fuel and Oil Additives - Facts and Myths/Maximizing Fuel Economy - (O
  16. #05-03-07-009A: Info - Wheel Alignment Specifications, Requirements and Recommendatio
  17. #05-03-10-005C: Performance Characteristics of Vehicles with Accessory Wheel/Tire Ass
  18. #05-03-10-020A: Use of Nitrogen Gas in Tires - (Jan 3, 2008)
  19. #05-06-01-018A: Accessory Drive Belt Chirp, Squeal or Squeak Type Noise at Cold Idle
  20. #05-07-30-018A: 1-2, 2-3, 3-4, 4-5 Shift and Torque Converter Clutch (TCC) Characteri
  21. #05-08-51-008B: Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove
  22. #05086A: Product Safety - Power Steering Hose Fracture - (Nov 16, 2005)
  23. #06-01-39-002C: Blower Motor Inoperative or May Not Shut Off in Extremely Low Ambient
  24. #06-03-09-004A: Squeak Noise From Rear of Vehicle (Lubricant Rear Leaf Springs) - (Oc
  25. #06-06-01-006B: Information on 6.6L LBZ, LB7, LLY Duramax Diesel Engine Cylinder Head
  26. #06-06-01-007A: Information on Identifying Duramax Diesel LB7, LLY, LMM, LBZ Overpowe
  27. #06-06-04-041: Info on Utra Low Sulfur Diesel Fuel and Warning Labels on Fuel Station
  28. #06-06-04-063C: 6.6L Duramax LBZ, LLY, LMM Diesel Engine EGR Valve Motor is Now Servi
  29. #06-06-04-066B: LBZ LLY Engine with Rough Idle, Poor Performance, Black/White Exhaust
  30. #06-07-30-013: Allison Transmission - Vehicle Shudder When Driving in 6th Gear Range
  31. #06-08-44-015A: Information on Eliminating Noise in Audio System When Using Portable
  32. #06-08-61-003B: Underbody Pop or Clunk Type Noise While Turning or Driving on Uneven
  33. #07-03-10-008: Information on Slight or Mild Tire Feathering and Recommended Practice
  34. #07-04-19-003: Front Axle Fluid Leak (Inspect for Kinked Axle Vent Tube) - (Nov 14, 2
  35. #07-06-01-003: LBZ LB7 LLY 6.6L Duramax Diesel Engine Accessory Drive Belt Chirp, Squ
  36. #07-06-01-010: Information on Duramax and Isuzu Diesel Engine Low Ash Oil-New Oil Rem
  37. #07-06-04-033: LMM, Clean Exhaust Filter Light Illuminated, MIL/SES Light Illuminated
  38. #07-08-50-018A: Excessive Lint Accumulation on Cloth Seats (Parts Not Yet Available)
  39. #07293B: Customer Satisfaction - Transmission Overheat in Extreme Cold Air Temperatur
  40. #07320A: Customer Satisfaction - Front Axle Vent Tube Kinked - Fluid Leak - (Mar 6, 2
  41. #08-06-04-006A: Information on Identifying Non-GM Calibration Usages for Lmm Duramax
  42. #99-04-20-002D: Information on Driveline Clunk Noise When Shifting Between PARK and D
  43. #99-08-51-007C: Info - Refinishing Aluminum Wheels - (Jun 19, 2006)
  44. #99-08-52-005C: Remote Keyless Entry Operational Characteristics - (Jan 30, 2008)
  45. #04039B: Special Coverage Adjustment - Injectors-Replace - (Nov 19, 2007)
  46. #PIP3722A: Diesel Engine Extended Idle Smoking - keywords 6.6 black blue excessive fu
  47. #05-06-04-047C: Service Engine Soon (SES) Light On with Reduction in Engine Power, DT
  48. #07057: Special Coverage Adjustment - Engine Glow Plug - (Feb 13, 2008)
  49. #00064G: Special Coverage (Policy) Adjustment - Electronic Diesel-Fuel Injection Pump
  50. #06522: Product Emission-Engine Glow Plug System Concern-Reprogram Glow Plug Control
  51. #08-08-49-002: False Triggering of Low Coolant Level Warning Message (Reprogram HVAC
  52. #02-06-01-023F: Oil Leak at Oil Cooler to Engine Block Mating Surface (Replace O-ring
  53. #08-06-04-029: LBZ, LLY, MIL/SES Light On, DTC P0087 - Fuel Rail Pressure (FRP) Too L
  54. #00-08-42-010A: Info - Daytime Running Lamp (DRL) Bulb Replacement - (Jun 20, 2003)
  55. #02-06-01-027A: Information on Higher Than Expected Oil Consumption - (May 17, 2005)
  56. #08142: Customer Satisfaction - ECM EEPROM - Reprogram ECM - (May 12, 2008)
  57. #08179: Service Update for Inventory and Customer Vehicles-Turbocharger Vane Position
  58. #08-06-04-032: Information on Diesel Fuel Requirements - Service Engine Soon (SES) In
  59. #07-06-04-033A: LMM, Clean Exhaust Filter Light Illuminated, MIL/SES Light Illuminate
  60. #PIP4105G: Duramax Diesels With DTC P009E - keywords 6.6 6.6L cal calibration code co
  61. #05-09-41-001B: Supplemental Inflatable Restraint (SIR) Light ON, Diagnostic Trouble
  62. #06-06-01-007B: Identifying Duramax Diesel LB7, LLY, LMM, LBZ Overpower Engine Breakd
  63. #08-06-03-007: No Start, No Crank, Intermittent Electrical Operations (Check for Poor
  64. #PIT3665A: Brake Pedal Moves Or Self Applies At Full Turns - keywords booster hydrobo
  65. #PIP4372B: Oil Leak At Turbocharger Air Intake Pipe - keywords 6.6 BQMI CAC charge cl
  66. #PIP4430: Fuel Rail Pressure Sensor Performance DTC P0191 - keywords 6.6 diesel engin
  67. #06-06-04-066C: LBZ, LLY Engine MIL/SES Light On With DTC P0403 Set (Check/Reprogram
  68. #04-06-04-007H: Service Engine Soon (SES) Light On, DTCs P0087, P0092, P1093, Low Pow
  69. #08-06-04-006C: Information on Identifying Non-GM Calibration Usages for LBZ, LLY, LM
  70. #08-08-49-016A: EI08347-DTC P0463, Fuel Gauge/Gage Inaccurately Reads Empty, Low Fuel
  71. #08-08-44-030: Various XM Traffic Event Functions Inoperative or Not Working Correctl
  72. #08048B: Product Safety - Heated Windshield Washer Module Short Circuit - Add Wire Ha
  73. #08259A: Customer Satisfaction - OnStar System Inoperative - Replace OnStar Module -
  74. #PIT4633C: Gap At B-Pillar Trim And Door Weather Strip - keywords away b body carpet
  75. #PIT4467A: Pop Rattle Clunk Squeak Knock During Turns Braking Accelerating - keywords
  76. #PIT3189K: Disabling Auto Door Locks - keywords DIC IPC lock manual mode operation pr
  77. #PIT4665A: ABS Traction Control And/Or Stabilitrak Lights On With No DTCs - keywords
  78. #PIT3559B: Low Brake Fluid Level Source Of Leak Unknown - keywords booster cylinder l
  79. #PIT4595C: Service Trailer Brake Message With DTC C1114 and/or C1112 - keywords conne
  80. #PIT3078D: Grease Leak From Front Hub Bearings - keywords axle brake front knuckle ro
  81. #PIP4020F: Groan Clunk Or Bump Noise From Launch Or At Stop - keywords moan pop squaw
  82. #PIT3098B: Vehicle Lean Diagnostic Information - keywords body box front left sag spr
  83. #08-08-110-002: Information on Slit or Cut in Front Floor Carpet or Rubber Floor Cove
  84. #09-06-93-001: Engine Oil Leaks from Charge Air Cooler and Turbocharger Air Inlet Ada
  85. #08-06-04-029C: LBZ, LLY, LMM MIL/SES Light On, DTC P0087-Fuel Rail Pressure (FRP) To
  86. #09-04-21-002A: Transfer Case Rear Output Shaft Oil Seal Leak (Replace Rear Output Sh
  87. #08-07-30-049A: Transmission Oil Cooler Line Leak (Replace Affected Cooler Line) - (M
  88. #08-06-03-006A: Engine Running with Key Off, Continuous Run - Sensing and Diagnostic
  89. #08-06-04-054: Snow Intrusion into Air Cleaner, Check Engine Light On, Engine Reduced
  90. #06-08-61-003D: Underbody Pop or Clunk Type Noise While Turning or Driving on Uneven
  91. #08-08-49-002: False Triggering of Low Coolant Level Warning Message (Reprogram HVAC
  92. #04-06-04-001C: LB7/LBZ/LLY/LMM - Intermittent Driveability Conditions-No Crank, Cran
  93. #01-03-10-010G: Inspection of Tire and Wheel Size Prior to Diagnosis of Transmission
  94. #04-06-04-070B: Information on Improved Fuel Filter for 6.6L Duramax Diesel Engine -
  95. #09-08-49-013: Proper Removal and Installation of Roof Console for Any Related Servic
  96. #09-01-38-004: Information for Vehicles with HVAC Control Module A/C and Recirculatio
  97. #07-08-44-001D: Information on Difficult to Install Radio Fixed Antenna Mast - (Jul 2
  98. #07-06-01-016B: Information on Internal Engine Noise or Damage After Oil Filter Repla
  99. #08-06-01-008A: Diagnosing Accessory Drive Belt/Serpentine Belt Noise and Availabilit
  100. #08-03-10-004A: Mounting, Balancing and Installation of Accessory Wheels and Tires Av
  101. #09-08-44-013A: Information on USB Command and Control Multimedia Player Interface/Li
  102. #01-03-10-010G: Inspection of Tire and Wheel Size Prior to Diagnosis of Transmission
  103. #06-00-89-029E: Interior Cleaning-Instrument Panel (IP), Hard or Plastic Surfaces, Se
  104. #06-08-44-015B: Information on Eliminating Noise in Audio System When Using Portable
  105. #09-03-16-002: Dealership Service Consultant Procedure as Vehicle Comes Into Service
  106. #01-08-42-001G: Exterior Lamp Condensation and Replacement Guidelines - (May 4, 2009)
  107. #08-03-10-005A: Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Ste
  108. #06-03-10-011E: 20 Inch and 22 Inch Accessory Wheels Available Through GM Accessories
  109. #09-00-89-015: 2010 Model Year Car and Light Duty Truck Vehicle Identification Number
  110. LB7: #04-06-04-001C: LB7/LBZ/LLY/LMM - Intermittent Driveability Conditions-No Crank, Cran
  111. #04-01-38-018: Info - HVAC Module External Seal Kit Now Available For Service Use - (
  112. #08-08-45-004A: Installation of Electrical Aftermarket Accessories - Battery, Ignitio
  113. #06-06-01-007E: Information on Identifying Duramax Diesel LB7, LLY, LMM, LBZ Overpowe
  114. #09-06-04-022B: Malfunction Indicator Lamp (MIL) Illuminated, Intermittent DTC P0191,
  115. #08-06-04-054A: Snow or Ice Ingestion into Air Cleaner Element, Malfunction Indicator
  116. #08-06-04-003A: New Tool Availability - EN-48974-EGR Cooler Pressure Tester Adapter S
  117. #PIP4540C: Early Oil Change Message Or Erratic Oil Life Monitor - keywords DIC miles
  118. #09285: Product Emission - Service Engine Soon Light Illuminated - Exhaust Gas Recirc
  119. #03-06-04-036B: Information on Servicing Duramax Diesel Fuel Injectors to Avoid and R
  120. #08-06-04-006G: Identifying Non-GM ECM Calibration Usages and Power-Up Hardware Detec
  121. #07-06-01-009A: 6.6L LB7, LLY Duramax Diesel Engine Cylinder Head Gasket Missing Thic
  122. #06-06-01-006C: Information on 6.6L LBZ, LB7, LLY Duramax Diesel Engine Cylinder Head
  123. #PIP4143B: U0106 Loss Of Communication With Glow Plug Control Module - keywords 6.6 6
  124. #09038: Customer Satisfaction - Enhanced Calibration for Transmission Overheat in Ext
  125. #09-06-04-034: Malfunction Indicator Lamp (MIL) Illuminated, Fuel Injector Driver Cir
  126. #PIP4683: P0101 Inspect Air Cleaner Assembly - keywords 6.6 6.6L box diesel DTC engin
  127. #03-07-29-004F: Manual Transmission Operating Characteristics - (Jul 29, 2009)
  128. #08-06-04-029C: LBZ, LLY, LMM MIL/SES Light On, DTC P0087-Fuel Rail Pressure (FRP) To
  129. #02-06-01-022J: Information on Engine Ticking Noise - (Apr 24, 2009)
  130. #PIP3224C: Damaged Turbo Chargers When Returned To The WPC - keywords 6.6 6.6L diesel
  131. #10-06-05-002: Clean Exhaust Filter See Owners Manual Now Message Displayed on Driver
  132. #02-07-30-051A: Transmission Shifting In and Out of 4th and 5th Gear (Hunting) When P